Specifications
| Frequency | 60.0 Hz |
|---|---|
| Standby power | 30 kW |
| Prime power | 26 kW |
| Emissions | Tier II |
| Oil capacity | 10.5 L |
| Voltage options | 120 V, 240 V, 125 V, 220 V, 118 V |
| Phase | 1 |
| Rated current | [125, 118] A |
| Power factor | [1.0] |
| Dimensions (L×W×H) | 1321×610×777 mm |
| Dry weight | 539 kg |
Engine
| Oil capacity | 10.0 L |
|---|---|
| Displacement | 3.33 L |
| Aspiration | naturally aspirated |
| Rated speed | 1800 rpm |
Maintenance & consumables
for the Lugger L944| Item | Spec | Capacity | Part # | Interval | |
|---|---|---|---|---|---|
| Air filter | — | find | |||
| Fuel filter | — | find | |||
| Oil filter | — | find | |||
| Belt | — | find | |||
| Coolant | — | ||||
| Oil | 10.5 | — | 250 hr |
Common questions
What is the power rating of the Northern Lights M944?
The Northern Lights M944 is rated 30 kW standby.
What engine does the Northern Lights M944 use?
The Northern Lights M944 is powered by the Lugger L944 engine.
What is the oil capacity of the Northern Lights M944?
The Lugger L944 engine in the Northern Lights M944 has an oil capacity of 10.0 liters.
Troubleshooting
3Symptoms & remedies
| Symptom | Remedy |
|---|---|
| Temperature gauge above 205° F (96° C) | Shut off the engine immediately. Use the Trouble Shooting Guide on page 25 to isolate the cause of the overheat. Allow the engine to cool and then remove the cap slowly using protective clothing. Make repairs and restart after the temperature gauge registers below 200° F (94° C). Watch the temperature gauge regularly and turn off the unit if the temperature rises above 205° F (96° C). Repeat troubleshooting. |
| Engine oil consumption greater during break-in | Oil consumption is greater during break-in as piston rings take time to seat. Break-In Oil Changes: Change engine oil and filter at 50 hours. Change oil and filter again at 100 hours (consult Lubricants section for oil recommendation). |
| Engine does not start after 3 consecutive 20-second cranks | Remove the impeller from the seawater pump. This will prevent the muffler from fi lling with water and backfi lling the exhaust line and engine. Once the engine starts, shut if off immediately and reinstall the impeller. Restart and check the exhaust overboard outlet for gushes of water. |
Fault codes and symptom→remedy steps extracted from this model’s service/owner documentation; verify against the official manual before servicing.
Parts
38| Part # | Description | Qty | System | |
|---|---|---|---|---|
| 05-01260 | Sound Enclosure | Sound enclosure | buy | |
| 05-71250 | Sound Enclosure | Sound enclosure | buy | |
| 06-73100 | Sound Enclosure | Sound enclosure | buy | |
| 06-78000 | Sound Enclosure | Sound enclosure | buy | |
| 06-78100 | Sound Enclosure | Sound enclosure | buy | |
| 06-78600 | Sound Enclosure | Sound enclosure | buy | |
| 06-78700 | Sound Enclosure | Sound enclosure | buy | |
| 22-45600 | Circuit Breaker 100 ft. | Circuit breaker | buy | |
| 22-45601 | Y Harness | Y harness | buy | |
| 22-45610 | Circuit Breaker 10 ft. | Circuit breaker | buy | |
| 22-45620 | Circuit Breaker 20 ft. | Circuit breaker | buy | |
| 22-45630 | Circuit Breaker 30 ft. | Circuit breaker | buy | |
| 22-45640 | Circuit Breaker 40 ft. | Circuit breaker | buy | |
| 22-45650 | Circuit Breaker 50 ft. | Circuit breaker | buy | |
| 22-45670 | Circuit Breaker 70 ft. | Circuit breaker | buy | |
| 22-62125 | S-3B Panel 12v/24v | Control panel | buy | |
| 22-65425 | S-3B Panel 12v/24v | Control panel | buy | |
| 22-70235 | S-3B Panel 12v/24v | Control panel | buy | |
| 22-70240 | S-3B Panel 12v/24v | Control panel | buy | |
| 22-70250 | S-3B Panel 12v/24v | Control panel | buy | |
| 22-70260 | S-3B Panel 12v/24v | Control panel | dieselpartscenter $50.81 | |
| 22-70280 | S-3B Panel 12v/24v | Control panel | buy | |
| 22-70300 | S-3B Panel 12v/24v | Control panel | buy | |
| 22-70350 | S-3B Panel 12v/24v | Control panel | buy | |
| 22-70375 | S-3B Panel 12v/24v | Control panel | buy | |
| 22-93101 | Tough Series Controller 1ph Single Volt Off Unit M773LW3 | Controller | buy | |
| 22-93102 | Tough Series Controller 1ph Single Volt Off Unit M843NW3 | Controller | buy | |
| 22-95600 | S-1 Panel 12v/24v | Control panel | buy | |
| 22-95601 | S-3B Panel 12v/24v | Control panel | buy | |
| 22-95605 | S-1B Panel 12v/24v | Control panel | buy | |
| 22-95610 | Tough Series Controller 1ph Single Volt Off Unit M864W3/M944T/M944W3F/M944T3F | Controller | buy | |
| 22-95611 | S-3C Panel 12v | Control panel | buy | |
| 22-95612 | S-3C Panel 14v | Control panel | buy | |
| 22-98021 | Tough Series Controller 1ph Single Volt Off Unit M673LD3 | Controller | buy | |
| 22-98412 | Tough Series Controller 1ph Single Volt Off Unit M844DW3/M844LW3 | Controller | buy | |
| 05-78010 | Sound Enclosure Assembly Instructions | Service part / kit | buy | |
| OM944F | Safety Rules (Continued) | 1 | Service part / kit | buy |
| ONL944 | Industrial Generator Set Component Locations | 7/13 | Service part / kit | buy |
Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.
Fuel consumption
| Rating | Load | L/h | gal/h |
|---|---|---|---|
| Prime | 5.3 | ||
| Prime | 50% | 5.3 | |
| Prime | 100% | 9.8 | |
| Standby | 9.8 |
Available documents
Spec sheetOperator's manualReference