Service parts for the RC115D
Grouped by system, with how many of each the parts manual calls for.
Air intake
1 requiredFuel system
1 requiredOil system
1 requiredPrices captured from merchant listings; some links are affiliate links. Confirm against your serial number before ordering.
Specifications
| Fuel | Diesel |
|---|---|
| Oil capacity | 12.0 L |
| Alternator | Leroy-Somer LSA 42.2/43.2/44.2/46.2/47.2 (4-pole) |
| Voltage options | 120/208 V, 277/480 V, 120/240 V |
| Battery voltage | 12 V |
| Dimensions (L×W×H) | 4211×1821×2123 mm |
| Dry weight | 2612 kg |
| Fuel tank | 719.2 L |
Engine
| Oil capacity | 12.0 L |
|---|---|
| Coolant capacity | 12.5 L |
| Displacement | 4.5 L |
| Aspiration | 4-Cycle |
| Rated speed | 1800 rpm |
Maintenance & consumables
for the John Deere 4045HF285| Item | Spec | Capacity | Part # | Interval | |
|---|---|---|---|---|---|
| Air filter | Air Cleaner Element (Engine) Primary | G030073 | Amazon eBay | ||
| Fuel filter | — | ||||
| Fuel filter | Element, Fuel Water Separator | CO2775 | Amazon eBay | ||
| Oil filter | Element, Oil Filter | C04521 | Amazon eBay | ||
| Oil | 12.0 L | — |
Common questions
What engine does the Clarke RC115D use?
The Clarke RC115D is powered by the John Deere 4045HF285 engine.
What kind of fuel does the Clarke RC115D run on?
The Clarke RC115D runs on Diesel.
What is the oil capacity of the Clarke RC115D?
The John Deere 4045HF285 engine in the Clarke RC115D has an oil capacity of 12.0 liters.
Which alternator is fitted to the Clarke RC115D?
The Clarke RC115D uses a Leroy-Somer LSA 42.2/43.2/44.2/46.2/47.2 alternator. It has 4 poles.
What oil filter does the Clarke RC115D use?
The Clarke RC115D uses oil filter part number C04521.
Which fuel filter part number does the Clarke RC115D take?
The Clarke RC115D uses fuel filter part number CO2775.
What air filter does the Clarke RC115D use?
The Clarke RC115D uses air filter part number G030073.
Troubleshooting
6Symptoms & remedies
| Symptom | Cause | Remedy |
|---|---|---|
| Excessive overheating of one or both bearings (temp of bearings over 80°C) (With or without abnormal bearing noise) | If the bearing has turned blue or if the grease has turned black, change the bearing. | |
| Excessive overheating of alternator frame (temperature rise of more than 40°C above ambient) | Air flow (inlet-outlet) partially clogged or hot air is being recycled either from alternator or prime mover. Alternator is functioning at too high a voltage (over 105% of rated voltage on load). Alternator overloaded | |
| Too much vibration | Misalignment (coupling) Defective mounting or play in coupling Incorrect balancing of shaft (Engine-Alternator) | |
| No voltage at no load or startup | Connect a battery of 4 to 12 volts to terminals E+(F+) or E-(F-) respecting the polarity on the A.V.R for 2 to 3 seconds. The alternator builds up and voltage is correct when the battery is removed. | |
| Lack of residual magnetism in alternator | - Check the connections of the sensing leads to the A.V.R. - Faulty rotating diode - Short-circuit on rotor windings | |
| Voltage collapses during normal operation | Check the AVR, the surge suppressor, the rotating diodes and replace any defective part |
Fault codes and symptom→remedy steps extracted from this model’s service/owner documentation; verify against the official manual before servicing. Full Clarke RC115D troubleshooting guide (12 entries) →
Parts
17| Part # | Description | Qty | System | |
|---|---|---|---|---|
| C04521 | Element, Oil Filter | Oil filter | Amazon eBay | |
| CO2775 | Element, Fuel Water Separator | Fuel filter | Amazon eBay | |
| CO2776 | Element, Fuel Filter Primary | Fuel filter | Amazon eBay | |
| G030071 | Air Cleaner Element (Engine) Secondary | Air filter | Amazon eBay | |
| G030073 | Air Cleaner Element (Engine) Primary | Air filter | Amazon eBay | |
| G030074 | Air Cleaner Element (Engine) Secondary | Air filter | Amazon eBay | |
| G122208 | Clarke Eng Fluid - 5 gal | Fluid | Amazon eBay | |
| G122209 | Clarke Eng Fluid -1 gal | Fluid | Amazon eBay | |
| G30070 | Air Cleaner Element (Engine) Primary | Air filter | Amazon eBay | |
| G122189 | 250 hour Maintenance Kit (without fluids) | Service part / kit | Amazon eBay | |
| G122190 | 250 hour Maintenance Kit (without fluids) | Service part / kit | Amazon eBay | |
| G122194 | 250 hour Maintenance Kit (& engine fluids) | Service part / kit | Amazon eBay | |
| G122195 | 250 hour Maintenance Kit (& engine fluids) | Service part / kit | Amazon eBay | |
| G122199 | 500 hour Maintenance Kit (without fluids) | Service part / kit | Amazon eBay | |
| G122200 | 500 hour Maintenance Kit (without fluids) | Service part / kit | Amazon eBay | |
| G122204 | 500 hour Maintenance Kit (& Engine fluids) | Service part / kit | Amazon eBay | |
| G122205 | 500 hour Maintenance Kit (& Engine fluids) | Service part / kit | Amazon eBay |
Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.