Service parts for the vh4d
Grouped by system, with how many of each the parts manual calls for.
Oil system
1 requiredPrices captured from merchant listings; some links are affiliate links. Confirm against your serial number before ordering.
Specifications
Ratings spec sheet not in our library yet — see the documents below.
Maintenance & consumables
for the Wisconsin VH4D| Item | Spec | Capacity | Part # | Interval | |
|---|---|---|---|---|---|
| Air filter | — | ||||
| Fuel filter | — | ||||
| Oil filter | Fig. 1 - Oil Filter | 277786C | Amazon eBay | ||
| Battery | — | ||||
| Belt | — | ||||
| Coolant | — | ||||
| Coolant filter | — | ||||
| Oil | good quality engine oil | 4.0 | — | ||
| Spark plug | — |
Compatible filters for the Wisconsin VH4D — cross-referenced via Donaldson. Options to verify against your serial number, not confirmed for this exact unit.
- Air filter: Wisconsin LO177 Wisconsin LO189 Donaldson P181050 Donaldson P181052 Wix 42276
- Fuel filter: Donaldson P550012 Donaldson P555095 Donaldson P550094 Wix 33032 Ac Delco GF142
Common questions
What engine is in the Wisconsin vh4d?
The Wisconsin vh4d is powered by the Wisconsin VH4D engine.
What oil filter fits the Wisconsin vh4d?
The Wisconsin vh4d uses oil filter part number 277786C.
What fuel filter does the Wisconsin vh4d use?
The Wisconsin vh4d uses fuel filter part numbers Donaldson P550012, Donaldson P555095.
What air filter does the Wisconsin vh4d use?
The Wisconsin vh4d uses air filter part numbers WISCONSIN LO177, WISCONSIN LO189.
Troubleshooting
2Symptoms & remedies
| Symptom | Cause | Remedy |
|---|---|---|
| Battery Overcharge | Test 1.0 Engine not running check battery with DC Voltmeter. I. 1 If voltage is greater than 13.5 volts 1.2 With engine running at full RPM, check battery voltage with DC Voltmeter. I. 3 If the charge increases beyond 13.5 volts. 1.4 If the charge remains under 13.5 volts. | 1.1 Place 12 volt light bulb or carbon pile across battery to reduce voltage to below 13.5 volts. 1.3 Faulty regulator, replace, -- static check regulator per 'rest No. 5.1.' 1.4 Alternator functioning properly. Check battery condition. |
| Low/No Charge | Test 2.0 2.1 Proceed with Test 1.0 and 1.1. It is necessary to slightly discharge battery to make system work. With engine running at full RPM, check battery voltage with DC Voltmeter. If the charge rate increases -- 2.3 If system does not charge 2.4 If charge rate increased with regulator disconnected. 2.5 If charge rate does not increase with regulator disconnected. | 2.2 Alternator functioning properly. [Battery was fully charged. 2.3 Operate engine with regulator disconnected (continue with Test 2.4). 2.4 Regulator was at fault. Replace regulator module, - static check regulator per Test No. 5.1. 2.5 Regulator not at fault. Check Rectifier per Test 3.0, 3.1 or static check per Test 6.0. |
Fault codes and symptom→remedy steps extracted from this model’s service/owner documentation; verify against the official manual before servicing.
Parts
31| Part # | Description | Qty | System | |
|---|---|---|---|---|
| 277786C | Fig. 1 - Oil Filter | Oil filter | Amazon eBay | |
| 636194 | Variable Speed Governor Control Switch | Ignition-starting | Amazon | |
| 63819C | Variable Speed Governor Control Switch | Ignition-starting | Amazon eBay | |
| 93194230-1 | Fig. 20 Flywheel Alternator (10 and 25 amp systems) with belt driven alternator and solid state ignition - CONNECT TO CHARGE SIDE OF AMMETER | Belt | Amazon eBay | |
| 93C81-66-35 | Valve and seat, fuel (for 4-8) | 1 | Fuel | Amazon eBay |
| 93T41-8 | Lever and stop, throttle (for 1, 2, 4) | 1 | Throttle | Amazon eBay |
| 93T57-4 | Shaft and lever, throttle (for 1, 2) | 1 | Throttle | Amazon eBay |
| C161-83 | Main Jet Wrench | 1 | Tool | Amazon |
| C161-85 | Fuel Valve Seat Wrench | 1 | Tool | Amazon |
| 244949C | Fig. 17, VH4D, W4-1770 Clutch Adjustment | Service part / kit | Amazon eBay | |
| 275568C | Fig. 18, VH4D, W4-1770 VG4D, V465D Clutch Adjustment | Service part / kit | Amazon eBay | |
| 3265-8/97 | Starting and Operating Manual | Service part / kit | buy | |
| 93C105-3 | Shaft, choke (for 1-5) | 1 | Service part / kit | Amazon eBay |
| 93C106-2 | Lever assembly, choke clamp (for 15) | 1 | Service part / kit | Amazon eBay $24.10 |
| 93C109-60 | Screw, lever stop | 1 | Service part / kit | Amazon eBay |
| 93C140-58 | Screw, bracket (for 1-5, 7, 8) | 1 | Service part / kit | Amazon eBay |
| 93T22S8 | Nut, choke lever nut | 1 | Service part / kit | Amazon eBay |
| 93T41-10 | Spring, choke lever (for 1-4) | 1 | Service part / kit | Amazon eBay |
| 93T8S8-7 | Screw, lever swivel (for 1-5, 8) (NLA) | 1 | Service part / kit | Amazon eBay |
| LZ77BS1 | Washer, choke shaft packing (for 1-3) | 1 | Service part / kit | Amazon eBay |
| LZ77CS1 | Screw, tube clamp (for 1-5, 8) | 1 | Service part / kit | Amazon eBay |
| LZ77GS1 | Nut, clamp screw (for 1-5, 8) | 1 | Service part / kit | Amazon eBay |
| LZ77S1 | Retainer, choke shaft packing (for 1-3) | 1 | Service part / kit | Amazon eBay |
| PD11 | Nut, 3/8"-24 thread | 1 | Service part / kit | Amazon eBay |
| PD79 | Nut, 3/8"-16 thread | 1 | Service part / kit | Amazon eBay $9.95 |
| PM210 | Bracket, choke (for 1-5, 7, 8) | 1 | Service part / kit | Amazon eBay |
| QD616 | Overhaul kit | 1 | Service part / kit | Amazon eBay $4.50 |
| XD33 | Screw, 3/8"-16 x 2-1/4" long | 1 | Service part / kit | Amazon eBay |
| Y97S2 | Washer, 3/8" steel | 1 | Service part / kit | Amazon eBay $90.00 |
| YC-66-D-S1 | High temperature safety switch | 1 | Service part / kit | Amazon eBay $139.99 |
| YL100A | Ignition cable set | 1 | Service part / kit | Amazon eBay $44.95 |
Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.
Available documents
Engine spec — VH4D (Wisconsin)Reference — WISCON High Temp Safety Switch Kits (Wisconsin)Parts manual — dual fuel sys (Wisconsin)Service manual — VH4D Repair (Wisconsin)Service manual — WISCON Operating Manual VH4D W4-1770 VG4D V465D 1997 (Wisconsin)Service manual — magnetos (Wisconsin)