Specifications
| Fuel | Diesel |
|---|---|
| Frequency | 60.0 Hz |
| Standby kVA | 45000 |
| Controller | DSE 7310 MKII |
| Oil capacity | 13.5 L |
| Alternator | Stamford/AvK UCI 224 D |
| Voltage options | 120/240 V, 120/208 V, 277/480 V |
| Phase | Three |
| Rated current | 187 A |
| Power factor | 1.0 |
| Circuit breaker | 175 A |
| Battery voltage | 12 V |
| Battery quantity | 1 |
| Coolant capacity | 50 L |
| Max ambient | 125 °C |
Engine
| Oil capacity | 13.5 L |
|---|---|
| Coolant capacity | 50.0 L |
| Displacement | 4.5 L |
| Aspiration | Natural |
| Rated speed | 1800 rpm |
Filters & service parts
model family| Item | Spec | Capacity | Part # | Interval | |
|---|---|---|---|---|---|
| Air filter | 50/50 mix | 16200-028 | 200 hr | PartsGeek | |
| Fuel filter | 50/50 mix | 16200-019 | 200 hr | PartsGeek | |
| Oil filter | 50/50 mix | 16200-025 | 200 hr | PartsGeek | |
| Belt | 50/50 mix | 16200-013 | 200 hr | PartsGeek | |
| Oil | 50/50 mix | 50.0 L | 16200-022 | 200 hr | PartsGeek |
Compiled from this model's family documentation — may include parts for closely-related variants. Confirm the exact part for your serial number.
Common questions
What engine does the Winco DR45F4 use?
The Winco DR45F4 is powered by the Iveco/FPT N45 SM1 4.5L engine.
What fuel does the Winco DR45F4 use?
The Winco DR45F4 runs on Diesel.
What is the oil capacity of the Winco DR45F4?
The Iveco/FPT N45 SM1 4.5L engine in the Winco DR45F4 has an oil capacity of 13.5 liters.
What alternator does the Winco DR45F4 use?
The Winco DR45F4 uses a Stamford/AvK UCI 224 D alternator.
What oil filter does the Winco DR45F4 use?
The Winco DR45F4 uses oil filter part number 16200-025.
What fuel filter does the Winco DR45F4 use?
The Winco DR45F4 uses fuel filter part number 16200-019.
What air filter does the Winco DR45F4 use?
The Winco DR45F4 uses air filter part number 16200-028.
Troubleshooting
7Symptoms & remedies
| Symptom | Cause |
|---|---|
| Unit will not crank when power fails | Digital genset not in AUTO Transfer control switch not in AUTOMATIC position Incorrect wiring between ATS and genset Defective control relay in ATS Fuse(s) blown in the DSE 7310 MKII Defective DSE 7310 MKII Loose or dirty battery terminals Defective starter Defective start solenoid Low/dead battery |
| Engine won’t crank | Low/dead battery Blown DC fuses Defective DSE 7310 MKII Defective key switch Loose or dirty battery terminals Defective starter Defective start solenoid |
| Engine cranks but will not start | Improper fuel delivery to the unit Fuel supply shut off Fuel tank empty Air in the fuel system Engine fuel solenoid has not opened Defective fuel pump Defective fuel solenoid Defective engine harness Improper battery voltage to fuel pump or fuel solenoid |
| Engine starts, then stops and alarm light comes on | Engine oil pressure is low Engine has high water temperature Engine has overspeed Engine has gone into overcrank |
| No output from AC generator | Loss of speed signal Loss of run signal Engine will not come up to speed after it starts Insufficient fuel volume getting to the unit 1. Too small of fuel line 2. Fuel racks not open properly Governor is defective AC short in generator components |
| ATS will not transfer to Emergency Supply (generator) | No AC generator output Defective ATS control board. See ATS manual Circuit breaker open or defective |
| ATS will not re-transfer to normal power | Proper power line not available at line terminals in ATS panel Defective ATS control board. See ATS manual |
Fault codes and symptom→remedy steps extracted from this model’s service/owner documentation; verify against the official manual before servicing.
Parts
5| Part # | Description | Qty | System | |
|---|---|---|---|---|
| 16200-013 | Belt | 1 | Belt | PartsGeek |
| 16200-019 | Fuel Filter | 1 | Fuel filter | PartsGeek |
| 16200-022 | Oil | 1 | Fluid | PartsGeek |
| 16200-025 | Oil Filter | 1 | Oil filter | PartsGeek |
| 16200-028 | Air Filter | 1 | Air filter | PartsGeek |
Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.
Fuel consumption
| Rating | Load | L/h | gal/h |
|---|---|---|---|
| Prime | 100% | 1.8 | 6.5 |
| Standby | 100% | 1.8 | 6.5 |