Specifications
| Fuel | diesel |
|---|---|
| Frequency | 60.0 Hz |
| Prime power | 33 kW |
| Oil capacity | 9.0 L |
| Alternator | Northern Lights W-Series (Class H insulation) |
| Voltage options | 120 V, 240 V |
| Phase | 1 |
| Rated current | 137 A |
| Power factor | 1 |
| Max ambient | 50 °C |
| Dimensions (L×W×H) | 1386×594×766 mm |
| Dry weight | 553 kg |
Maintenance & consumables
| Item | Spec | Capacity | Part # | Interval | |
|---|---|---|---|---|---|
| Air filter | — | 200 hr | find | ||
| Fuel filter | 24-50002 | 200 hr | Amazon eBay $34.85 PartsGeek | ||
| Oil filter | 24-05401 | 200 hr | Amazon eBay $33.15 PartsGeek | ||
| Belt | V-belt tension | — | 50 hr | find | |
| Coolant | 50% water / 50% ethylene glycol antifreeze | — | 600 hr | ||
| Oil | SAE 30W | 9.0 liters | — | 200 hr |
Common questions
What fuel does the Northern Lights M984W use?
The Northern Lights M984W runs on diesel.
What alternator does the Northern Lights M984W use?
The Northern Lights M984W uses a Northern Lights W-Series alternator. Insulation class H.
Troubleshooting
11Symptoms & remedies
| Symptom | Cause | Remedy |
|---|---|---|
| Battery Will Not Charge | Loose or corroded connections Sulfated or worn out batteries Loose or defective alternator belt | Clean and tighten battery connections. Check specific gravity of each battery. Check electrolyte level of each battery. Adjust belt tension. Replace belt. |
| Starter Inoperative | Check DC circuit breaker Loose or corroded connections Low battery condition Defective electrical system ground wire: | If the breaker is tripped, reset it. Clean and tighten loose battery and harness plug connection. Check specific gravity of each battery. Check electrolyte level of each battery. Repair or replace. |
| Starter Cranks Slowly | Low battery condition Check specific gravity of each battery Check electrolyte level of each battery Crankcase oil too heavy Loose or corroded connections Battery is too small. Battery cables are too small. | If low, fill cells with distilled water. Fill with oil of appropriate viscosity. Clean and tighten loose connections. |
| Entire Electrical System Does Not Function | Check DC circuit breaker Faulty connection Sulfated or worn out batteries | If breaker is tripped, reset it. Clean and tighten battery and harness plug connections. Check specific gravity and electrolyte level of each battery. |
| Engine Hard to Start or Will Not Start | Improper starting procedure No fuel Low battery condition Excessive resistance in starting circuit Crankcase oil too heavy Improper type of fuel Water, dirt or air in fuel system Clogged primary fuel filter element Clogged secondary fuel filter element Dirty or faulty injection nozzles | See starting section of this manual. Take special note of Bypass Switch operation. Check level of fuel in fuel tank. Check electrolyte level and condition. Clean and tighten all battery connections. Use oil of proper viscosity. Consult fuel supplier and use proper type of fuel for operating condition. Drain, flush, fill and bleed system. Clean or replace filter element. Replace filter element. Have your dealer check injection nozzles. |
| Engine Runs Irregularly or Stalls Frequently | Below normal engine temperature Clogged primary fuel filter element Clogged secondary fuel filter element | |
| Dirty or faulty injection nozzles | Have your dealer check injection nozzles. | |
| Air in fuel system | Inspect clamps and hoses on suction side of fuel pump for air leak. | |
| Improper type of fuel | Consult fuel supplier and use proper type of fuel for operating condition. | |
| Lack of Engine Power | Engine overloaded | Reduce the load. |
| Engine Overheats | Engine overloaded | Reduce the electrical load. |
Fault codes and symptom→remedy steps extracted from this model’s service/owner documentation; verify against the official manual before servicing.
Parts
44| Part # | Description | Qty | System | |
|---|---|---|---|---|
| 185046210 | Alternator Assembly | 1 | Alternator | PartsGeek |
| 24-05401 | Oil filter | Oil filter | Amazon eBay $33.15 PartsGeek | |
| 24-50002 | Primary fuel filter | Fuel filter | Amazon eBay $34.85 PartsGeek | |
| 24-52020 | Fuel filter | Fuel filter | Amazon eBay $24.71 PartsGeek | |
| 90430-10027 | Gasket | 1 | Gasket | PartsGeek |
| 040126210 | Bearing | 2 | Service part / kit | PartsGeek |
| 11011-78300-71 | Thrust Washer Set, Standard Only | 1 | Service part / kit | PartsGeek FridayParts $34.00 |
| 11012-78300-71 | Thrust Washer Set O/S, 0.125 mm | 1 | Service part / kit | PartsGeek |
| 11013-78300-71 | Thrust Washer Set O/S, 0.25 mm | 1 | Service part / kit | PartsGeek |
| 11461-78700-71 | Cylinder Liner (Dry Type) (Mark A) | 4 | Service part / kit | PartsGeek |
| 11461-78701-71 | Cylinder Liner (Dry Type) (Mark B) | 4 | Service part / kit | PartsGeek |
| 11701-78700-71 | Main Bearing, Size 1 - Standard [up to S/N 0042812] | 5 | Service part / kit | PartsGeek |
| 11701-78701-71 | Main Bearing, Size 2 - Standard [up to S/N 0042812] | 5 | Service part / kit | PartsGeek |
| 11701-78702-71 | Main Bearing, Size 3 - Standard [up to S/N 0042812] | 5 | Service part / kit | PartsGeek |
| 11701-78703-71 | Main Bearing, Size 1 - Standard [from S/N 0042813] | 5 | Service part / kit | PartsGeek |
| 11701-78704-71 | Main Bearing, Size 2 - Standard [from S/N 0042813] | 5 | Service part / kit | PartsGeek |
| 11701-78705-71 | Main Bearing, Size 3 - Standard [from S/N 0042813] | 5 | Service part / kit | PartsGeek |
| 11701-78706-71 | Main Bearing, Size 4 - Standard [from S/N 0042813] | 5 | Service part / kit | PartsGeek |
| 11701-78707-71 | Main Bearing, Size 5 - Standard [from S/N 0042813] | 5 | Service part / kit | PartsGeek |
| 11701-78708-71 | Main Bearing, Size 6 - Standard [from S/N 0042813] | 5 | Service part / kit | PartsGeek |
| 11704-78700-71 | Main Bearing Set, 0.25 mm, Undersize | 1 | Service part / kit | PartsGeek |
| 11705-78700-71 | Main Bearing Set, 0.50 mm, Undersize | 1 | Service part / kit | PartsGeek |
| 11706-78700-71 | Main Bearing Set, 0.75 mm, Undersize | 1 | Service part / kit | PartsGeek |
| 11707-78700-71 | Main Bearing Set, 1.00 mm, Undersize | 1 | Service part / kit | PartsGeek |
| 13011-78700-71 | Piston Ring Set, Standard [up to S/N 0042812] | 1 | Service part / kit | PartsGeek |
| 13011-78701-71 | Piston Ring Set, Standard [from S/N 0042813] | 1 | Service part / kit | PartsGeek |
| 13013-78700-71 | Piston Ring Set, 0.50 mm, Oversize [up to S/N 0042812] | 1 | Service part / kit | PartsGeek |
| 13013-78701-71 | Piston Ring Set, 0.50 mm, Oversize [from S/N 0042813] | 1 | Service part / kit | PartsGeek |
| 13015-78700-71 | Piston Ring Set, 1.00 mm, Oversize [up to S/N 0042812] | 1 | Service part / kit | PartsGeek |
| 13015-78701-71 | Piston Ring Set, 1.00 mm, Oversize [from S/N 0042813] | 1 | Service part / kit | PartsGeek |
| 13041-68040-01 | Connecting Rod Bearing, Mark 1 - Standard | 4 | Service part / kit | PartsGeek |
| 13041-68040-02 | Connecting Rod Bearing, Mark 2 - Standard | 4 | Service part / kit | PartsGeek |
| 13101-78700-71 | Piston Assembly, Standard (includes Key #21A) [up to S/N 0042812] | 4 | Service part / kit | PartsGeek |
| 13101-78702-71 | Piston Assembly, Standard (includes key #21A) [from S/N 0042813] | 4 | Service part / kit | PartsGeek |
| 13103-78700-71 | Piston Assembly, 0.50 mm O/S (includes Key #21A) [up to S/N 0042812] | 4 | Service part / kit | PartsGeek |
| 13103-78701-71 | Piston Assembly, 0.50 mm O/S (includes key #21A) [from S/N 0042813] | 4 | Service part / kit | PartsGeek |
| 13105-78700-71 | Piston Assembly, 1.00 mm O/S (includes Key #21A) [up to S/N 0042812] | 4 | Service part / kit | PartsGeek |
| 13105-78701-71 | Piston Assembly, 1.00 mm O/S (includes key #21A) [from S/N 0042813] | 4 | Service part / kit | PartsGeek |
| 13204-78300-71 | Connecting Rod Bearing Set, 0.25 mm, Undersize | 1 | Service part / kit | PartsGeek |
| 13205-78300-71 | Connecting Rod Bearing Set, 0.50 mm, Undersize | 1 | Service part / kit | PartsGeek |
| 13206-78300-71 | Connecting Rod Bearing Set, 0.75 mm, Undersize | 1 | Service part / kit | PartsGeek |
| 13207-78300-71 | Connecting Rod Bearing Set, 1.00 mm, Undersize | 1 | Service part / kit | PartsGeek |
| 185446218 | Stator, complete | 1 | Service part / kit | PartsGeek |
| 90384-32951-71 | Wrist Pin Bushing | 4 | Service part / kit | PartsGeek |
Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.
Fuel consumption
| Rating | Load | L/h | gal/h |
|---|---|---|---|
| 9.8 | 2.6 | ||
| 50% | 5.3 | 1.4 | |
| 100% | 9.8 | 2.6 |
Available documents
Spec sheet — M984W (Northern Lights)Owner's manual — OM984W (Northern Lights)Parts manual — P984-I (Northern Lights)Parts manual — P984 (Northern Lights)