Service parts for the M1166AMCA
Grouped by system, with how many of each the parts manual calls for.
Air intake
1 requiredFuel system
1 requiredOil system
1 requiredBelts
1 requiredPrices captured from merchant listings; some links are affiliate links. Confirm against your serial number before ordering.
Specifications
| Standby power | 168 kW |
|---|---|
| Prime power | 143 kW |
| Phase | 3 |
Maintenance & consumables
| Item | Spec | Capacity | Part # | Interval | |
|---|---|---|---|---|---|
| Air filter | Air Filter | 24-21000 | Amazon eBay | ||
| Fuel filter | Final Filter Element (2 Micron) | RE506428 | Amazon eBay $45.00 | ||
| Oil filter | Filter Element | RE509672 | Amazon eBay $36.00 NAPA $33.32 KuduParts $16.00 FridayParts $18.57 | ||
| Belt | Drive Belt (not shown) | 40-02502 | eBay |
Common questions
What is the power rating of the Northern Lights M1166AMCA?
The Northern Lights M1166AMCA is rated 168 kW standby.
What is the prime power rating of the Northern Lights M1166AMCA?
The Northern Lights M1166AMCA is rated 143 kW prime, against 168 kW standby.
What oil filter does the Northern Lights M1166AMCA use?
The Northern Lights M1166AMCA uses oil filter part number RE509672.
What fuel filter fits the Northern Lights M1166AMCA?
The Northern Lights M1166AMCA uses fuel filter part number RE506428.
What air filter does the Northern Lights M1166AMCA use?
The Northern Lights M1166AMCA uses air filter part number 24-21000.
Troubleshooting
6Symptoms & remedies
| Symptom | Cause | Remedy |
|---|---|---|
| Engine Hard to Start or Will Not Start | Engine starting under load; Improper starting procedure | See starting section of this manual. Take special note of Bypass Switch operation. |
| Engine Hard to Start or Will Not Start | No fuel | Check level of fuel in fuel tank. |
| Engine Hard to Start or Will Not Start | Low battery output | Check electrolyte level and condition. |
| Engine Hard to Start or Will Not Start | Excessive resistance in starting circuit | Clean and tighten all battery connections. |
| Engine Hard to Start or Will Not Start | Crankcase oil too heavy | Use oil of proper viscosity. |
| Engine Hard to Start or Will Not Start | Improper type of fuel | Consult fuel supplier and use proper type of fuel for operating condition. |
Fault codes and symptom→remedy steps extracted from this model’s service/owner documentation; verify against the official manual before servicing. Full Northern Lights M1166AMCA troubleshooting guide (90 entries) →
Parts
47| Part # | Description | Qty | System | |
|---|---|---|---|---|
| 18-59517 | Hose Assembly, 5/16” ID x 25” | 1 | Hose | eBay |
| 18-59713 | Hose Assembly, 5/16” ID x 21” | 1 | Hose | eBay |
| 22-40277 | Alternator, 24 Volt 75 Amp | 1 | Alternator | buy |
| 22-40357 | Oil Pressure Switch 25 PSI | 1 | Sensor | eBay |
| 22-40364 | Temperature Switch 2350F | 1 | Sensor | eBay |
| 22-40905 | Temperature Switch 2250F | 1 | Sensor | buy |
| 22-40915 | Switch, Pressure 15 PSI | 1 | Sensor | Amazon eBay |
| 22-42802 | Coolant Temperature Sender | 1 | Sensor | Amazon eBay |
| 22-42803 | Oil Pressure Sender | 1 | Sensor | Amazon eBay |
| 22-49503 | Starter 24 Volt Isolated Ground | 1 | Starter | eBay |
| 24-20018 | Crankcase Breather Filter, Right hand | 1 | Air filter | eBay |
| 24-21000 | Air Filter | 1 | Air filter | Amazon eBay |
| 40-02502 | Drive Belt (not shown) | 1 | Belt | eBay |
| AR48675 | Thermostat, 180°F (82°C) | 2 | Thermostat | Amazon eBay $12.49 FridayParts $14.99 |
| R124607 | Gasket | 1 | Gasket | eBay |
| R130573 | Gasket | 3 | Gasket | eBay |
| R504009 | Gasket | 1 | Gasket | eBay |
| R521548 | Thermostat Seal RIng | ** | Seal | eBay |
| R86062 | Gasket | 1 | Gasket | eBay |
| RE151433 | Coolant Temperature Sensor | 1 | Sensor | eBay FridayParts $26.99 |
| RE167207 | Sensor | 1 | Sensor | eBay $20.24 FridayParts $34.13 |
| RE48419 | Sensor | 1 | Sensor | eBay FridayParts $18.40 |
| RE503676 | PRIMARY FUEL FILTER | 1 | Fuel filter | Amazon eBay $49.95 NAPA $76.78 KuduParts $54.00 |
| RE503677 | Sediment Bowl | 1 | Fuel filter | eBay |
| RE504628 | Fuel filter | Fuel filter | Amazon | |
| RE505743 | Oil Filter | 1 | Oil filter | eBay |
| RE506194 | Sensor | 1 | Sensor | eBay |
| RE506428 | Final Filter Element (2 Micron) | 1 | Fuel filter | Amazon eBay $45.00 |
| RE509463 | O-ring Kit | 1 | Seal | eBay |
| RE509672 | OIL FILTER | 1 | Oil filter | Amazon eBay $36.00 NAPA $33.32 KuduParts $16.00 FridayParts $18.57 |
| RE515638 | Hand Priming Pump (includes key #50) | 1 | Pump | eBay FridayParts $35.00 |
| RE516171 | Seal Kit | 1 | Seal | eBay |
| RE518726 | Fuel Injector | 6 | Injector | eBay SinoCMP $229.00 FridayParts $871.65 |
| RE519144 | Speed Sensor | 2 | Sensor | eBay FridayParts $19.00 |
| RE521058 | Gasket Kit, Engine Rebuild (also order seal kit RE516171) | 1 | Gasket | eBay |
| RE521059 | Gasket Kit, Cylinder Head | 1 | Gasket | eBay |
| RE521422 | Fuel Injection Pump, HPCR 12V | 1 | Pump | eBay SinoCMP $1169.00 FridayParts $1490.99 |
| RE521423 | Fuel Injection Pump, HPCR 24V | 1 | Pump | eBay FridayParts $1407.00 |
| RE521496 | Seal Kit | 1 | Seal | eBay |
| RE521503 | Coolant Pump (includes keys 2- 6) | 1 | Pump | Amazon eBay $149.99 |
| RE55475 | Engine Cylinder Head Gasket | 1 | Gasket | eBay FridayParts $60.87 |
| RE61812 | Air Temperature Sensor | 1 | Sensor | eBay FridayParts $39.90 |
| RE62776 | Gasket (use with exhaust manifolds R120645, R504711, or R504712) | 2 | Gasket | eBay |
| RE62777 | Gasket (use with exhaust manifolds R120645, R504711, or R504712) | 2 | Gasket | eBay |
| AT13740 | Drain Valve | 1 | Service part / kit | Amazon eBay FridayParts $12.10 |
| OM1166 | Operator's Manual for Models: M1166AMCA and M1166AR | 1 | Service part / kit | Amazon eBay |
| RE500726 | Filler Cap | 1 | Service part / kit | buy |
Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.
Available documents
This page was generated from the 1 manufacturer document above by automated extraction; every figure shown is copied from one of them. How the data is compiled.