Service parts for the 3.0 L
Grouped by system, with how many of each the parts manual calls for.
Air intake
1 requiredPrices captured from merchant listings; some links are affiliate links. Confirm against your serial number before ordering.
Specifications
| Oil capacity | 4.0 L |
|---|---|
| Coolant capacity | 4 L |
Maintenance & consumables
for the 3.0L L4| Item | Spec | Capacity | Part # | Interval | |
|---|---|---|---|---|---|
| Air filter | Air Filter | 36100022-12 | Amazon eBay | ||
| Oil filter | Oil Filter - P-25 or Equivalent | 94632619 | Amazon eBay $4.50 NAPA $9.09 |
Common questions
What engine does the General Motors 3.0 L use?
The General Motors 3.0 L is powered by the 3.0L L4 engine.
What's the oil capacity on a General Motors 3.0 L?
The None 3.0L L4 engine in the General Motors 3.0 L has an oil capacity of 5.0 liters.
What is the cooling system capacity of the General Motors 3.0 L?
The General Motors 3.0 L cooling system holds 4 liters (1.1 US gallons) for the radiator system including the engine, per the manufacturer specification sheet.
Which oil filter part number does the General Motors 3.0 L take?
The General Motors 3.0 L uses oil filter part number 94632619.
What air filter does the General Motors 3.0 L use?
The General Motors 3.0 L uses air filter part number 36100022-12.
Troubleshooting
6Fault codes
| Code | Meaning | Remedy |
|---|---|---|
| #14 | PRE-HI ENGINE TEMP LED. Engine continues to operate — Indicates engine has begun to overheat and engine temperature has risen to approximately 215°F (105°C). If generator is powering non critical and critical loads and cannot be shut down. Use the following: | Reduce load if possible by turning off non-critical loads; Check air inlets and outlets and remove any obstructions to airflow; Open doors or windows in generator area to increase ventilation; If engine can be stopped, follow procedure in Step 2 |
| 2 | HI ENGINE TEMP LED. Engine shuts down — Indicates engine has overheated (engine temperature has risen above 225°F/110°C) or coolant level is low (sets with coolant level sensor). | Allow engine to cool down completely before proceeding with the following checks: Check coolant level and replenish if low. Look for possible coolant leakage points and repair if necessary; Check for obstructions to cooling airflow and correct as necessary; Check for a slipping fan belt and tighten if loose; Reset control and restart after locating and correcting problem. Contact your Dealer or Distributor if none of the above |
| *3 | PRE LOW OIL PRESSURE LED. Engine continues to operate — Indicates engine oil pressure has dropped to 20 psi (138kPa). If generator is powering critical loads and cannot be shut down, wait until next shutdown period and then follow Step 4 procedure. If engine can be stopped, follow procedures in Step 4. | |
| 4 | LOW OIL PRESSURE LED. Engine shuts down — Indicates engine oil pressure has dropped to 15 psi (97kPa). NOTE: See also Step 5 | Check oil level, lines and filters. If oil system is okay, but oil level is low, replenish. Reset control and restart. Contact your Dealer or Distributor if oil pressure is not in the range of 35 to 55 psi (21 to 379 kPa) |
| 5 | OVERCRANK LED. Engine stops cranking. Or Engine runs, shuts down, and LOW OIL PRESSURE LED — Indicates possible fuel system problem. | Check for empty fuel tank, fuel leaks, or plugged fuel lines and correct as required; Check for dirty fuel filter and replace if necessary (See Maintenance section of Engine Manual); Check for dirty or plugged air filter and replace if necessary (See Maintenance section of Engine Manual); Refer to Step 4; Reset the control and restart after correcting the problem. Contact your Dealer or Distributor for service if none of the above |
| 6 | Engine runs and then shuts down, OVERSPEED LED — Indicates engine has exceeded normal operating speed. | Refer to governor adjust procedure. Contact your Dealer or Distributor for service |
Fault codes and symptom→remedy steps extracted from this model’s service/owner documentation; verify against the official manual before servicing. Full General Motors 3.0 L troubleshooting guide (51 entries) →
Parts
69| Part # | Description | Qty | System | |
|---|---|---|---|---|
| 1052365 | Lubricant | Lubricant | Amazon eBay | |
| 36100022-12 | Air Filter | 1 | Air filter | Amazon eBay |
| 5030T | Engine model | Engine | Amazon eBay | |
| 94632619 | Oil Filter | 1 | Oil filter | Amazon eBay $4.50 NAPA $9.09 |
| GM90538 | Camshaft Position Sensor | 1 | Sensor | Amazon eBay $154.89 |
| O17024BR | End Brush | Air filter | Amazon eBay | |
| P822768 | Air Filter - Primary (PSI Power Unit) | 1 | Air filter | Amazon eBay $32.72 NAPA $58.60 KuduParts $88.00 FridayParts $89.99 |
| P822769 | Air Filter - Safety (PSI Power Unit) | 1 | Air filter | Amazon eBay KuduParts $88.00 |
| VE005-3L | Engine Block | Engine | Amazon eBay | |
| VE006-3L | Engine Block | Engine | Amazon eBay | |
| VE008-3L | Coolant Thermostat Housing Bolt | Thermostat | Amazon eBay | |
| VE009-3L | Coolant Thermostat Housing Bolt | Thermostat | Amazon eBay | |
| VE018-3L | Water Pump Bolt | Pump | Amazon eBay | |
| VE033-3L | Crankshaft Sprocket Puller J 6978-E | Tool | Amazon eBay | |
| VE034-3L | Dial Indicator J 8001 | Tool | Amazon eBay | |
| VE035-3L | Crankshaft Sprocket Puller J 6978-E | Tool | Amazon eBay | |
| VE036-3L | Connecting Rod Guide Tool J 5239 | Tool | Amazon eBay | |
| VE037-3L | Ridge Reamer J 24270 | Tool | Amazon eBay | |
| VE038-3L | Connecting Rod Guide Tool J 5239 | Tool | Amazon eBay | |
| VE040-3L | Crankshaft Rear Oil Seal Puller J 6098-01 | Tool | Amazon eBay | |
| VE042-3L | Crankshaft Rear Oil Seal Puller J 6098-01 | Tool | Amazon eBay | |
| VE043-3L | Crankshaft Rear Oil Seal Puller J 6098-01 | Tool | Amazon eBay | |
| VE044-3L | Crankshaft Rear Oil Seal Housing Bolt | Seal | Amazon eBay | |
| VE045-3L | Crankshaft Rear Oil Seal Puller J 6098-01 | Tool | Amazon eBay | |
| VE046-3L | Crankshaft Rear Oil Seal Housing Bolt | Seal | Amazon eBay | |
| VE047-3L | Magnetic Base Indicator Set J 7872 | Tool | Amazon eBay | |
| VE048-3L | Crankshaft Rear Oil Seal Puller J 6098-01 | Tool | Amazon eBay | |
| VE049-3L | Micrometer | Tool | Amazon eBay | |
| VE050-3L | Crankshaft Rear Oil Seal Puller J 6098-01 | Tool | Amazon eBay | |
| VE051-3L | Crankshaft Rear Oil Seal Housing Bolt | Seal | Amazon eBay | |
| VE052-3L | Crankshaft Rear Oil Seal Puller J 6098-01 | Tool | Amazon eBay | |
| VE053-3L | Micrometer | Tool | Amazon eBay | |
| VE054-3L | Camshaft Bearing Puller J 6098-01 | Tool | Amazon eBay | |
| VE055-3L | Camshaft Bearing Puller J 6098-01 | Tool | Amazon eBay | |
| VE056-3L | Distributor Lower Bushing Remover J 9534 | Tool | Amazon eBay | |
| VE057-3L | Slide Hammer J 6585 | Tool | Amazon eBay | |
| VE058-3L | Oil Filter Bypass Valve | Oil filter | Amazon eBay | |
| VE125-3L | Oil Nozzle | Injector | Amazon eBay | |
| VE126-3L | Oil Nozzle | Injector | Amazon eBay | |
| VE127-3L | Oil Nozzle | Injector | Amazon eBay | |
| VE128-3L | Spark Plug | Engine | Amazon eBay | |
| VE133-3L | Engine Block | Engine | Amazon eBay | |
| 33000036 | PSI Timing Connector | 1 | Service part / kit | Amazon eBay |
| D05223ST | Engine Repair Stand (Heavy Duty) | 1 | Service part / kit | Amazon eBay |
| LC50 | Main adjustment screw (MAS) settings are measured from the MAS valve body (not the jam nut) to the exterior end of the MAS screw. | Service part / kit | Amazon eBay FridayParts $19.99 | |
| VE010-3L | Fuel Rail Bracket Bolt | Service part / kit | Amazon eBay | |
| VE011-3L | Fuel Rail Bracket Bolt | Service part / kit | Amazon eBay | |
| VE012-3L | Engine Block | Service part / kit | Amazon eBay | |
| VE013-3L | Engine Block | Service part / kit | Amazon eBay | |
| VE014-3L | Intake/Exhaust Manifold Bolt | Service part / kit | Amazon eBay | |
| VE015-3L | Intake/Exhaust Manifold Bolt | Service part / kit | Amazon eBay | |
| VE016-3L | Engine Block | Service part / kit | Amazon eBay | |
| VE017-3L | Crankshaft Pulley Removal Tool | Service part / kit | Amazon eBay | |
| VE019-3L | Valve Rocker Arm Cover Bolt | Service part / kit | Amazon eBay | |
| VE020-3L | Pushrod Cover Bolt | Service part / kit | Amazon eBay | |
| VE021-3L | Valve Rocker Arm Cover Bolt | Service part / kit | Amazon eBay | |
| VE022-3L | Valve Rocker Arm Cover Bolt | Service part / kit | Amazon eBay | |
| VE023-3L | Valve Rocker Arm Cover Bolt | Service part / kit | Amazon eBay | |
| VE024-3L | Valve Lifter Removal Tool (Plier Type) | Service part / kit | Amazon eBay | |
| VE025-3L | Valve Lifter Removal Tool (Plier Type) | Service part / kit | Amazon eBay | |
| VE026-3L | Valve Lifter Removal Tool (Slide Hammer Type) | Service part / kit | Amazon eBay | |
| VE027-3L | Valve Lifter Removal Tool (Slide Hammer Type) | Service part / kit | Amazon eBay | |
| VE028-3L | Valve Lifter Removal Tool (Plier Type) | Service part / kit | Amazon eBay | |
| VE029-3L | Valve Lifter Removal Tool (Slide Hammer Type) | Service part / kit | Amazon eBay | |
| VE030-3L | Engine Front Cover | Service part / kit | Amazon eBay | |
| VE031-3L | Engine Front Cover | Service part / kit | Amazon eBay | |
| VE032-3L | Oil Pan Bolt | Service part / kit | Amazon eBay | |
| VE129-3L | Water Outlet Housing Bolt | Service part / kit | Amazon eBay | |
| VE130-3L | Engine Flywheel Bolt | Service part / kit | Amazon eBay |
Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.
Available documents
Engine spec — gm-3.0l-nglpg-specsheet (General Motors)Service manual — Cert. Stationary Operations and Mantainance Manual 36100014F (General Motors)
This page was generated from the 2 manufacturer documents above by automated extraction; every figure shown is copied from one of them. How the data is compiled.