Service parts for the GP7500E Series
Grouped by system, with how many of each the parts manual calls for.
Air intake
1 requiredPrices captured from merchant listings; some links are affiliate links. Confirm against your serial number before ordering.
Specifications
| Voltage options | 120/240 V |
|---|---|
| Phase | single-phase |
| Rated current | 30 A |
| Circuit breaker | [20, 30] A |
Maintenance & consumables
| Item | Spec | Capacity | Part # | Interval | |
|---|---|---|---|---|---|
| Air filter | Air Filter | 0G84420151 | Amazon eBay $35.00 | ||
| Fuel filter | Fuel Filter | 0H1326 | Amazon eBay $7.99 KuduParts $6.00 FridayParts $8.66 | ||
| Oil filter | — | 100 hr | |||
| Battery | When the battery will no longer accept a charge, replacement is necessary. The battery is needed to use the electric starter. | — | 365 hr | ||
| Belt | — | ||||
| Coolant | — | ||||
| Oil | Change engine oil after first 30 hours of operation. Change every month when operating under heavy load or in high temperatures. | — | 25 hr | ||
| Spark plug | Clean, gap or replace spark plug as follows: Never disconnect a spark plug with the engine running. Doing so will result in an electric shock that could result in death or serious injury. | — | 300 hr |
Common questions
What voltage does the Generac GP7500E Series produce?
The Generac GP7500E Series is offered in 120/240 V, single-phase-phase.
What fuel filter fits the Generac GP7500E Series?
The Generac GP7500E Series uses fuel filter part number 0H1326.
Which air filter part number does the Generac GP7500E Series take?
The Generac GP7500E Series uses air filter part number 0G84420151.
Troubleshooting
33Symptoms & remedies
| Symptom | Cause | Remedy |
|---|---|---|
| Engine is running, but no AC output is available | Circuit breaker is open | Reset circuit breaker |
| Engine is running, but no AC output is available | Poor connection or defective cord set | Check and repair |
| Engine is running, but no AC output is available | Connected device is bad | Connect another device that is in good condition |
| Engine is running, but no AC output is available | Fault in generator | Contact Authorized Service Facility |
| Engine runs well but bogs down when loads are connected | Short circuit in a connected load | Disconnect shorted electrical load |
| Engine runs well but bogs down when loads are connected | Generator is overloaded | See "Generator Loads" |
| Engine runs well but bogs down when loads are connected | Engine speed is too slow | Contact Authorized Service Facility |
| Engine runs well but bogs down when loads are connected | Shorted generator circuit | Contact Authorized Service Facility |
| Engine will not start; or starts and runs rough | Start/Run/Off switch is in STOP position | Place Start/Run/Off switch in START position |
| Engine will not start; or starts and runs rough | Start/Run/Off switch is not in RUN position | Place Start/Run/Off switch in RUN position |
| Engine will not start; or starts and runs rough | Fuel shut-off is OFF | Turn fuel shut-off ON |
| Engine will not start; or starts and runs rough | Dirty air filter | Clean or replace air filter |
| Engine will not start; or starts and runs rough | Dirty fuel filter | Replace fuel filter |
| Engine will not start; or starts and runs rough | Out of fuel | Fill the fuel tank |
| Engine will not start; or starts and runs rough | Spark plug wire not connected to spark plug | Connect wire to spark plug |
| Engine will not start; or starts and runs rough | Bad spark plug | Replace spark plug |
| Engine will not start; or starts and runs rough | Water in fuel | Drain fuel tank and replace with fresh fuel |
| Engine will not start; or starts and runs rough | Overchoking | Put choke knob to No Choke position |
| Engine will not start; or starts and runs rough | Low oil level | Fill crankcase to proper level |
| Engine will not start; or starts and runs rough | Excessive rich fuel mixture | Contact Authorized Service Facility |
| Engine will not start; or starts and runs rough | Intake valve stuck open or closed | Contact Authorized Service Facility |
| Engine will not start; or starts and runs rough | Engine has lost compression | Contact Authorized Service Facility |
| Engine shuts down during operation | Out of fuel | Fill the fuel tank |
| Engine shuts down during operation | Low oil level | Fill crankcase to proper level |
| Engine shuts down during operation | Dirty fuel filter | Change fuel filter |
| Engine shuts down during operation | Fault in engine | Contact Authorized Service Facility |
| Engine lacks power | Load is too high | Reduce load (see "Generator Loads") |
| Engine lacks power | Dirty air filter | Clean or replace air filter |
| Engine lacks power | Dirty fuel filter | Replace fuel filter |
| Engine lacks power | Engine needs to be serviced | Contact Authorized Service Facility |
| Engine "hunts" or falters | Carburetor is running too rich or too lean | Contact Authorized Service Facility |
| Engine "hunts" or falters | Dirty fuel filter | Replace fuel filter |
| Engine "hunts" or falters | Governor out of adjustment? | Contact authorized dealer facility |
Fault codes and symptom→remedy steps extracted from this model’s service/owner documentation; verify against the official manual before servicing.
Parts
6| Part # | Description | Qty | System | |
|---|---|---|---|---|
| 0G0752 | Oil (quart) | Fluid | Amazon eBay | |
| 0G84420101 | Spark Plug | Spark plug | Amazon eBay | |
| 0G84420151 | Air Filter | Air filter | Amazon eBay $35.00 | |
| 0G9449 | Battery Type: Lead Acid (12V DC, 9Ah) | 1 | Battery | Amazon eBay $25.99 |
| 0H1326 | Fuel Filter | 1 | Fuel filter | Amazon eBay $7.99 KuduParts $6.00 FridayParts $8.66 |
| 0K3029 | Battery Fuse | Service part / kit | Amazon eBay |
Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.
Available documents
Owner's manual — original (Generac)
This page was generated from the 1 manufacturer document above by automated extraction; every figure shown is copied from one of them. How the data is compiled.