Specifications
Ratings spec sheet not in our library yet — see the documents below.
Maintenance & consumables
| Item | Spec | Capacity | Part # | Interval | |
|---|---|---|---|---|---|
| Air filter | — | 500 hr | find | ||
| Fuel filter | — | 1000 hr | find | ||
| Oil filter | 901103 | 500 hr | PartsGeek FridayParts $26.89 | ||
| Belt | — | 500 hr | find | ||
| Coolant | — | 1000 hr | |||
| Coolant filter | — | find | |||
| Hydraulic filter | 57116 | PartsGeek FridayParts $40.60 | |||
| Oil | — |
Compatible filters — cross-referenced via Donaldson. Options to verify against your serial number, not confirmed for this exact unit.
- Air filter: Perkins 901048 Perkins 26510343 Donaldson P828889 Donaldson P829333 Wix 46562
Common questions
What oil filter does the Perkins 1104D-E44T use?
The Perkins 1104D-E44T uses oil filter part number 901103.
What air filter does the Perkins 1104D-E44T use?
The Perkins 1104D-E44T uses air filter part numbers PERKINS 901048, PERKINS 26510343.
Troubleshooting
42Fault codes
| Code | Meaning | Remedy |
|---|---|---|
| 551 | No Detected Faults have occurred since the ignition keyswitch has been turned to the ON position | Flash Code 551 indicates no faults. No further action required. |
| 111 | No. 1 Injector Fault | Schedule a Service. |
| 112 | No. 2 Injector Fault | Schedule a Service. |
| 113 | No. 3 Injector Fault | Schedule a Service. |
| 114 | No. 4 Injector Fault | Schedule a Service. |
| 133 | Intake Manifold Air Temperature sensor fault | Schedule a Service. |
| 141 | Primary Engine Speed/Timing Sensor Fault | Schedule a Service. |
| 142 | Secondary Engine Speed/Timing Sensor Fault | No specific remedy provided, but it is suggested to investigate the fault. |
| 143 | Engine Timing Calibration Fault | Schedule a Service. |
| 144 | Engine Operation Mode Selector Switch Fault | Schedule a Service. |
| 151 | Air Inlet Pressure Sensor Fault | Schedule a Service. |
| 154 | Throttle Position Sensor Fault | Schedule a Service. |
| 155 | Secondary Throttle Position sensor Fault | Schedule a Service. |
| 157 | Engine Oil Pressure Sensor Fault | Schedule a Service. |
| 159 | Fuel Rail Pressure Sensor Fault | Schedule a Service. |
| 162 | Fuel Rail Pressure Valve Solenoid Fault | Schedule a Service. |
| 168 | Engine Coolant Temperature Sensor Fault | No specific remedy provided, but it is suggested to investigate the fault. |
| 169 | Low Engine Coolant | No specific remedy provided, but it is suggested to investigate the fault. |
| 177 | Turbo Wastegate Actuator Fault | No specific remedy provided, but it is suggested to investigate the fault. |
| 185 | High Exhaust Temperature | No specific remedy provided, but it is suggested to investigate the fault. |
| 197 | Intake Manifold Boost Pressure Fault | Schedule a Service. |
| 199 | Glow Plug Start Relay Fault | No specific remedy provided, but it is suggested to investigate the fault. |
| 233 | Ether Injection Control Solenoid | Schedule a Service. |
| 245 | Idle Validation Switch 1 Fault | No specific remedy provided, but it is suggested to investigate the fault. |
| 246 | Idle Validation Switch 2 Fault | No specific remedy provided, but it is suggested to investigate the fault. |
| 253 | Engine Fuel Supply Pump Relay Fault | Schedule a Service. |
| 415 | Software Mismatch | No specific remedy provided, but it is suggested to investigate the fault. |
| X | Warning lamps are installed. | Refer to this table. For installations that have electronic displays, refer to the OEM for information. |
| 511 | ECM Power Supply Voltage Fault | |
| 514 | SAE J1939 Data Link Fault | |
| 516 | 5 Volt Sensor DC Power Supply Fault | |
| 517 | 8 Volt Sensor DC Power Supply Fault | |
| 527 | Customer/System Parameter Fault |
Symptoms & remedies
| Symptom | Cause | Remedy |
|---|---|---|
| Diagnostic lamp is activated | System detects an active problem | Refer to Troubleshooting, “Electronic Service Tools” for further information. |
| Active codes represent problems that currently exist | These problems should be investigated first. | |
| Logged codes represent intermittent problems, recorded events, and performance history | The problems may have been repaired since the logging of the code. These codes do not indicate that a repair is needed. | |
| Diagnostic lamp illuminates during normal engine operation. | Use electronic service tools to check the active diagnostic codes. | |
| Low oil pressure condition with 'DERATE' selected. | The Electronic Control Module (ECM) will limit the engine power until the problem is corrected. If the oil pressure is within the normal range, the engine may be operated at the rated speed and load. | |
| Active diagnostic code should be investigated. | The cause of the problem should be corrected as soon as possible. If the cause of the active diagnostic code is repaired and there is only one active diagnostic code, the diagnostic lamp will turn off. | |
| Diagnostic lamp illuminates during normal engine operation and shuts off. | An intermittent fault may have occurred. The operator should retrieve the logged fault codes and reference the appropriate information in order to identify the nature of the event. | |
| System configuration parameters affect the emissions or power of the engine. | The electronic service tool is required to alter the configuration parameters. System configuration parameters are programmed at the factory and do not require reprogramming if the ECM software is changed. | |
| Engine speed exceeds 3300 rpm | The event code E190 will be logged. The “DIAGNOSTIC” lamp will indicate a diagnostic fault code. The diagnostic fault code will remain active until the engine speed drops to 2800 rpm. |
Fault codes and symptom→remedy steps extracted from this model’s service/owner documentation; verify against the official manual before servicing.
Parts
49| Part # | Description | Qty | System | |
|---|---|---|---|---|
| 4133L066 | PERKINS 1104D-E44T, 1104D-E44TA, 1106D-E66TA THERMOSTAT | Thermostat | PartsGeek FridayParts $126.00 | |
| g03470356 | (14) Alternator | Alternator | PartsGeek | |
| g03471916 | (1) Coolant Temperature Sensor | Sensor | PartsGeek | |
| g03471957 | (7) Fuel Rail Pressure Sensor | Sensor | PartsGeek | |
| g03506649 | Turbocharge Engine View (Illustration 20) | 1 | Turbocharger | PartsGeek |
| i05488609 | Sensors and Electrical Components | Sensor | PartsGeek | |
| g00104545 | Illustration 4 | 1 | Service part / kit | PartsGeek |
| g00687600 | Always use a board or cardboard when you check for a leak. Leaking fluid that is under pressure can penetrate body tissue. Fluid penetration can cause serious injury and possible death. A pin hole leak can cause severe injury. If fluid is injected into your skin, you must get treatment immediately. Seek treatment from a doctor that is familiar with this type of injury. | 1 | Service part / kit | PartsGeek |
| g00702020 | Wear a hard hat, protective glasses, and other protective equipment, as required. | 1 | Service part / kit | PartsGeek |
| g00704000 | Illustration 8 | 1 | Service part / kit | PartsGeek |
| g00704059 | Illustration 9 | 1 | Service part / kit | eBay PartsGeek |
| g01154807 | Typical example | 2 | Service part / kit | PartsGeek |
| g01154858 | Typical example | 2 | Service part / kit | PartsGeek |
| g01187485 | Illustration 24 - Engine Parts | 1 | Service part / kit | PartsGeek |
| g02298225 | Gases from a battery can explode. Keep any open flames or sparks away from the top of a battery. Do not smoke in battery charging areas. | 1 | Service part / kit | PartsGeek |
| g02433756 | Typical example | Service part / kit | PartsGeek | |
| g03450122 | Hand (High Pressure) | Service part / kit | PartsGeek | |
| g03450123 | The warning label for the Hand (High Pressure) (2) | Service part / kit | PartsGeek | |
| g03452577 | Grounding Practices (Illustration 15) | 1 | Service part / kit | PartsGeek |
| g03452579 | Grounding Practices (Illustration 16) | 1 | Service part / kit | PartsGeek |
| g03453612 | Serial Number Plate (Illustration 24) | 1 | Service part / kit | PartsGeek |
| i02143194 | Crushing Prevention and Cutting Prevention | Service part / kit | PartsGeek | |
| i02234873 | Engine Stopping | 1 | Service part / kit | PartsGeek |
| i02251260 | Engine Starting | Service part / kit | PartsGeek | |
| i02330192 | Monitoring System | Service part / kit | PartsGeek | |
| i02651093 | Self-Diagnostics | Service part / kit | PartsGeek | |
| i02651107 | Diagnostic Lamp | Service part / kit | PartsGeek | |
| i02813489 | Before Starting Engine | Service part / kit | PartsGeek | |
| i04151489 | Perkins are not responsible for damage which may occur when an engine is in storage after a period in service. | Service part / kit | PartsGeek | |
| i04823662 | Fire Prevention and Explosion Prevention | Service part / kit | PartsGeek | |
| i05251301 | Alarms and Shutoffs | Service part / kit | PartsGeek | |
| i05251914 | Overspeed | Service part / kit | PartsGeek | |
| i05272352 | Engine Electronics (Operation Section) | 1 | Service part / kit | PartsGeek |
| i05302522 | Static Electricity Hazard when fueling with Ultra-low Sulfur Diesel Fuel | 1 | Service part / kit | PartsGeek |
| i05461290 | Safety Messages | Service part / kit | PartsGeek | |
| i05463929 | Mounting and Dismounting | Service part / kit | PartsGeek | |
| i05463931 | High Pressure Fuel Lines | Service part / kit | PartsGeek | |
| i05464430 | Electrical System Never disconnect any charging unit circuit or battery circuit cable from the battery when the charging unit is operating. | 1 | Service part / kit | PartsGeek |
| i05465764 | Reference Information | Service part / kit | PartsGeek | |
| i05536748 | Product Information - General Information | 1 | Service part / kit | PartsGeek |
| i05536753 | Product Description - Off Engine Parts and Options | 1 | Service part / kit | PartsGeek |
| i05536932 | Product Identification - Information (Illustration 23) | 1 | Service part / kit | PartsGeek |
| i05536952 | Emissions Certification Film | Service part / kit | PartsGeek | |
| i05537598 | Gauges and Indicators (Illustration 31) | 1 | Service part / kit | PartsGeek |
| i05537601 | Diagnostic Flash Code Retrieval | Service part / kit | PartsGeek | |
| i05546770 | Monitoring System | Service part / kit | PartsGeek | |
| i05737934 | General Hazard Information | Service part / kit | PartsGeek | |
| i07451407 | Operation Section - Lifting and Storage (Illustration 26) | 1 | Service part / kit | PartsGeek |
| i08315117 | General Hazard Information | Service part / kit | PartsGeek |
Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.
Fuel consumption
| Rating | Load | L/h | gal/h |
|---|---|---|---|
Available documents
Brochure — Perkins In China Industrial PN3015(chi) Crosspage (Perkins)Engine spec — 1104D-E44T Engine (PN1837 Jan08) (Perkins)Engine spec — 1104D-E44T Industrial PN3052 (Perkins)Engine spec — 1104D-E44T Irrigation pump power unit PN1952 Sep09 (Perkins)Engine spec — 1104D-E44T-Industrial-PN3052 (Perkins)Engine spec — 1104D-E44TA Engine (PN1838 Jan08) (Perkins)Engine spec — 1104D-E44TA IOPU PN1907 (Perkins)Engine spec — 1104D-E44TA-IOPU-PN1907 (Perkins)Engine spec — 1104d-e44t engine (pn1837 - may06) (Perkins)Engine spec — 1104d-e44ta engine (pn1838 - may06) (Perkins)Engine spec — Industrial Engine Ratings Guide PN3059 (Perkins)Engine spec — Industrial Lesser Regulated Engine Ratings Guide PN3008 (Perkins)Engine spec — Industrial Lesser Regulated Engine Ratings Guide PN3008Ru (Perkins)Engine spec — Irrigation Engine Ratings Guide PN3024 (Perkins)Engine spec — PN1949 Perkins Irrigation Engine Ratings Guide (Perkins)Spec sheet — 1104D-E44TA Industrial PN3051 (Perkins)Spec sheet — 1104D-E44TA Irrigation Pump Power Unit PN1944 sep09 (Perkins)Service manual — Perkins 1104D-E44T Series Operation & Maintenance Manual (Perkins)