Name: Perkins 1100D Series Generator Set
Brand: Perkins

Specifications

Ratings spec sheet not in our library yet — see the documents below.

Engine

Coolant capacity	15.2 L
Displacement	6.6 L
Aspiration	turbocharged and intercooled
Rated speed	1800 rpm

Maintenance & consumables

for the Perkins 1106D

Item	Spec	Capacity	Part #	Interval
Air filter			SEBUS119-01	365 hr	buy
Air filter	clean or replace		—	66 hr	find
Belt	check or replace		—	57 hr	find
Coolant	test and add as needed	9.0	—	62 hr
Coolant filter			—		find
Fuel filter	1762811 POWERPART Lay-Up 2	102304789.0	—	79 hr	find
Oil		13.5	—
Oil filter	1734115 POWERPART Lay-Up 3	102304789.0	—	68 hr	find

Troubleshooting

Code	Symptom	Cause	Remedy
	If a diagnostic lamp illuminates during normal engine operation		Use the electronic service tool to check the active diagnostic codes. The cause of the problem should be corrected as soon as possible.
	If a fault has occurred, the fault will be logged into the memory of the Electronic Control Module (ECM).		Retrieve the logged fault codes and reference the appropriate information to identify the nature of the event. Log any observation that could have caused the lamp to light.
	If a diagnostic lamp illuminates during normal engine operation and the diagnostic lamp shuts off, an intermittent fault may have occurred.		Retrieve the logged fault codes. Reference the appropriate information to identify the nature of the event.
	If the engine has not been started for several weeks, fuel may have drained from the fuel system.		Prime the fuel system. Refer to the Operation and Maintenance Manual, “Fuel System - Prime” for more information on priming the fuel system.
	Do not start the engine or move any of the controls if there is a ‘DO NOT OPERATE’ warning tag or similar warning tag attached to the start switch or to the controls.		Reset all of the shutoffs or alarm components (if equipped). Ensure that any equipment driven by the engine has been disengaged from the engine. Minimize electrical loads or remove any electrical loads.
	An overspeed condition	engine speed exceeds 3000 rom
	Diagnostic active code indicated by the 'DIAGNOSTIC' lamp	Engine speed exceeding 2800 rpm after an overspeed condition
516	Sensor Supply Voltage Fault		Check Customer Parameters or System Parameters
527	System Parameters Fault		Check Customer Parameters or System Parameters
	A lower oil pressure is normal at low idle.		If the load is stable and the gauge reading changes, perform the following procedure: 1. Remove the load. 2. Stop the engine. 3. Check and maintain the oil level.
	The engine is operating above the normal range and steam becomes apparent.		1. Reduce the load and the engine rpm. 2. Determine if the engine must be shut down immediately or if the engine can be cooled by reducing the load. 3. Inspect the cooling system for leaks.
	No oil pressure is indicated.		STOP the engine.
	Maximum coolant temperature is exceeded.		STOP the engine.
	Engine derate occurs due to preset operational limits being exceeded.		The engine will be derated if the engine exceeds preset operational limits. The engine derate is achieved by restricting the amount of fuel that is available for each injection.
	Engine shutdown occurs due to low oil pressure or coolant temperature.		There will be a two second delay in order to verify the condition before shutdown.

Symptom → cause → remedy extracted from this model’s service/owner documentation; verify against the official manual before servicing.

Parts

101

Part #	Description	Qty	System
02255918	Engine Oil and Filter - Change		Oil filter	buy
02335774	Radiator - Clean		Cooling	buy
02336636	Hoses and Clamps - Inspect/Replace		Hose	buy
102307647	Alternator and Fan Belts - Replace		Belt	buy
102322515	Battery - Replace		Battery	buy
102326098	Starting Motor - Inspect		Starter	buy
102334301	Fuel System Primary Filter/Water Separator - Drain		Fuel filter	buy
102336405	Engine Air Cleaner Service Indicator - inspect		Air filter	buy
192330274	service or repair on the engine fuel lines		Fuel filter	buy
21825755	Perkins Liquid SCA		Coolant filter	buy
2527045	Fuel System Primary Filter (Water Separator) Element - Replace		Fuel filter	buy
901153445	Fuel Tank Water and Sediment - Drain		Fluid	buy
SEBU8119-01	Engine Crankcase Breather Element - Replace	102304789	Oil filter	buy
SEBU8119-014	Crankcase Breather (Canister) - Replace		Canister	buy
SEBU8119-04	jump start cables		Water pump	buy
SEBUS119-01	Air Filter Element (Dual Element)		Air filter	buy
SEBUS8119-01	Water Pump - Inspect		Water pump	buy
g00104545	Warning Tag for Bus Bar or Glow Plugs		Glow plug	buy
g00687600	Fluid Penetration Warning		Fluid penetration warning	buy
g00702020	Protective Equipment Warning		Protective equipment warning	buy
g00702022	Exhaust Fumes Warning		Exhaust fumes warning	buy
g00704059	Oil ﬁlters and fuel ﬁlters		Oil filter	eBay
g01249453	图61 (1) 排气预留孔		Hydraulic filter	buy
g01334883	Fuel filter base		Fuel filter	eBay
g02342216	Ether Warning		Ether warning	buy
g03342264	Safety warning sign (Hand High Pressure) - label for number 6 injector line	2	Injector	buy
i02654355	Fuel Priming Pump - Remove and Install (Electrical Priming Pump)	1	Pump	buy
i02654356	Fuel Priming Pump - Remove and Install (Mechanical Priming Pump)	1	Pump	buy
i02654496	Fuel Filter Base - Remove and Install (Secondary Fuel Filter)	1	Fuel filter	buy
i02654512	Fuel Transfer Pump - Install		Pump	buy
i02654514	Fuel Transfer Pump - Remove		Pump	buy
i03018695	起动马达- 检查		Air filter	buy
i03018731	排放保修信息		Belt	buy
i03616504	围绕检查检查发动机是否渗漏，连接处是否松动		Coolant filter	buy
i03616508	涡轮增压器- 检查		Oil filter	buy
i04148593	Universal Warning		Universal warning	buy
i04149629	Primary Fuel Filter		Filter	buy
i08312758	Do Not Operate Warning Tag		Do not operate warning tag	buy
iG2527034	Fuel System Filter - Replace		Fuel filter	buy
01902995	Engine Operation with Intermittent Diagnostic Codes		Service part / kit	buy
02143194	Safety Section - Prevention and Cutting Prevention		Service part / kit	buy
02234878	Engine Stopping		Service part / kit	buy
02304660	Fuel System - Prime		Service part / kit	buy
02307633	Alternator - Inspect		Service part / kit	buy
02321383	Engine Electronics - Warning and Grounding Practices		Service part / kit	buy
02322199	Before Starting Engine		Service part / kit	buy
02322201	Before Starting Engine		Service part / kit	buy
02322203	Starting the Engine		Service part / kit	buy
02322204	Starting with Jump Start Cables		Service part / kit	buy
02322260	Aftercooler Core - Clean/Test		Service part / kit	buy
02323088	Battery or Battery Cable - Disconnect		Service part / kit	buy
02323237	Fuel Related Components in Cold Weather		Service part / kit	buy
02325622	Mounting and Dismounting		Service part / kit	buy
02335775	Severe Service Application - Check		Service part / kit	buy
102237872	Refill Capacities		Service part / kit	buy
102251260	Engine Starting		Service part / kit	buy
102323090	Walk-Around Inspection		Service part / kit	buy
102334873	shutoff procedures		Service part / kit	buy
192325166	Cold Weather Starting		Service part / kit	buy
901162364	High Pressure Fuel Lines - Inspection		Service part / kit	buy
901165836	Engine Oil Level - Check		Service part / kit	buy
SCBU8119-02	操作部分	27	Service part / kit	buy
SEBU8728-04	Safety Section		Service part / kit	buy
g00704000	Fire Prevention and Explosion Prevention Warning		Service part / kit	buy
g00896263	Cylinder block		Service part / kit	buy
g00904874	Air inlet and exhaust system		Service part / kit	buy
g00904915	Turbocharger		Service part / kit	buy
g00940109	Typical example of the 1106 engine		Service part / kit	buy
g00976171	Crankshaft		Service part / kit	buy
g01154807	Safety warning sign (Universal Warning)	2	Service part / kit	buy
g01154809	乙醚警告标签(2)		Service part / kit	buy
g01154858	Safety warning sign (Hand High Pressure) - typical example	2	Service part / kit	buy
g01156334	Engine Air Precleaner - Check/Clean		Service part / kit	buy
g01158591	Illustration 25		Service part / kit	buy
g01177669	Hand (High Pressure) Warning Label		Service part / kit	buy
g01330220	图24: 功能部件和控制装置		Service part / kit	buy
g01330325	图25: 功能部件和控制装置		Service part / kit	buy
g01334857	Illustration 3		Service part / kit	buy
g01334872	Illustration 1		Service part / kit	buy
g01334899	Illustration 7 - Typical example		Service part / kit	buy
g01392790	Hand (High Pressure) Warning		Service part / kit	buy
g01392818	图23: 功能部件和控制装置		Service part / kit	buy
g03341746	Safety warning sign (Hand High Pressure)	2	Service part / kit	buy
gO1157129	Engine Valve Lash - Inspect/Adjust		Service part / kit	buy
i01802949	Fault Logging		Service part / kit	buy
i01845923	Left side view of the 1106 engine		Service part / kit	buy
i01884420	Basic Engine		Service part / kit	buy
i01889424	Welding on Engines with Electronic Controls		Service part / kit	buy
i02288680	Safety Messages		Service part / kit	buy
i02328435	Safety warning sign (Ether)	1	Service part / kit	buy
i02334785	Burn Prevention Warning		Service part / kit	buy
i02788195	Safety Messages		Service part / kit	buy
i03018734	起动发动机前的准备		Service part / kit	buy
i03616548	Oil and fuel recommendations		Service part / kit	buy
i03616564	高压燃油管		Service part / kit	buy
i03616567	Maintenance schedule		Service part / kit	buy
i05271111	Safety warning sign	1	Service part / kit	buy
i05302522	Safety warning sign (Burn Prevention)	1	Service part / kit	buy
i1S07674	Engine Oil Sample - Obtain		Service part / kit	buy
i61902948	Diagnostic Lamp		Service part / kit	buy
i61902951	Engine Operation with Active Diagnostic Codes		Service part / kit	buy

Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.

Fuel consumption

Rating	Load	L/h	gal/h

Prime
Standby

Available documents

BrochureReferenceService manual

Perkins 1100D Series Generator Set