Specifications
| Fuel | Diesel |
|---|---|
| Frequency | 60.0 Hz |
| Standby power | 50 kW |
| Standby kVA | 62 |
| Prime power | 40 kW |
| Controller | John Deere 6329D |
| Oil capacity | 12.0 L |
| Alternator | Cummins/Onan UR |
| Voltage options | 120/240 V, 115/230 V, 120/208 V, 127/220 V, 139/240 V, 110/190 V, 115/200 V, 240/416 V, 254/440 V, 277/480 V, 220/380 V, 230/400 V, 347/600 V |
| Phase | 3 |
| Rated current | 260 A |
| Power factor | 0.8 |
| Circuit breaker | 35 A |
| Battery group | 2H |
| Battery voltage | 12 V |
| Battery quantity | 2 |
| Coolant capacity | 5 L |
| Dimensions (L×W×H) | 2019×839×1335 mm |
| Dry weight | 1000 kg |
| Fuel tank | 3.9 L |
| Tank runtime | 10 hr |
Engine
| Oil capacity | 13.4 L |
|---|---|
| Coolant capacity | 18.9 L |
| Displacement | 5.39 L |
| Aspiration | naturally aspirated |
| Rated speed | 1800 rpm |
Maintenance & consumables
for the John Deere 6329D| Item | Spec | Capacity | Part # | Interval | |
|---|---|---|---|---|---|
| Air filter | 503-0648 | 503-0648 | 100 hr | PartsGeek | |
| Fuel filter | 505-0019 | 505-0019 | 100 hr | PartsGeek | |
| Oil filter | 503-0197 | 503-0197 | 100 hr | PartsGeek | |
| Belt | 309-0178 | 309-0178 | 100 hr | PartsGeek |
Common questions
What is the power rating of the Cummins/Onan DDB Series?
The Cummins/Onan DDB Series is rated 50 kW standby (62.5 kVA).
What engine does the Cummins/Onan DDB Series use?
The Cummins/Onan DDB Series is powered by the John Deere 6329D engine.
What fuel does the Cummins/Onan DDB Series use?
The Cummins/Onan DDB Series runs on Diesel.
What is the oil capacity of the Cummins/Onan DDB Series?
The John Deere 6329D engine in the Cummins/Onan DDB Series has an oil capacity of 13.4 liters.
What alternator does the Cummins/Onan DDB Series use?
The Cummins/Onan DDB Series uses a Cummins/Onan UR alternator.
What oil filter does the Cummins/Onan DDB Series use?
The Cummins/Onan DDB Series uses oil filter part number 503-0197.
What fuel filter does the Cummins/Onan DDB Series use?
The Cummins/Onan DDB Series uses fuel filter part number 505-0019.
What air filter does the Cummins/Onan DDB Series use?
The Cummins/Onan DDB Series uses air filter part number 503-0648.
Troubleshooting
13Symptoms & remedies
| Symptom | Remedy |
|---|---|
| Fault lamp lights and, engine stops cranking after approximately 75 seconds. | See engine service manual for troubleshooting fuel system, ignition system, etc. After correcting problem, reset the engine monitor by moving run-stop/reset-remote switch to reset position. Release and return to run position. |
| Fault lamp lights immediately after engine starts. | Check for: a. overspeed condition as engine starts. b. high temperature condition. c. faulty high engine temperature sensor or overspeed switch. d. faulty starter disconnect. |
| Fault lamp lights after engine is running. | Check the following: a. Oil level-engine will shut down after approximately 12-172'seconds if low oil pressure sensor does not open. b. Oil pressure sensor may be defective. c. High engine temperature - caused by low coolant level, faulty thermostat, etc. d. Faulty high engine temperature sensor. e. Faulty starter disconnect. |
| Fault lamp lights - no fault condition exists. | Be certain that no fault condition exists. Disconnect lead 29, 30 and 31 from TB11 inside control box (refer to wiring diagram). If fault lamp still lights with leads disconnected, remove and replace engine monitor plug-in printed circuit board. |
| Overcrank fault lamp lights and engine stops cranking after approximately 75 seconds. | See engine service manual for troubleshooting fuel system, ignition system, etc. After correcting fault, reset monitor by moving run-stop/reset-remote switch to reset position, then to either run or remote to restart engine. |
| Overcrank fault lamp lights after engine has run for approximately 75 seconds. | Replace start-disconnect circuit board. |
| High engine temperature lamp lights as soon as engine starts. | Check for defective sensor or actual high temperature condition. |
| Low oil pressure lamp lights after engine is running. | Check: a. Oil level - engine will shut down after approximately 12-1/2 seconds if oil pressure is low. |
| High engine temperature lamp lights after engine is running. | Check for: a. Defective thermostat/thermostats. b. Low coolant level. c. Defective high engine temperature sensor. |
| Overspeed lamp lights - no fault condition exists. | Replace overspeed circuit board. |
| Low oil pressure fault lamp lights r no fault condition exists. | Be certain that no fault condition exists. Disconnect lead 30 from TB11 inside control box (refer to wiring diagram). If low oil pressure lamp still lights, remove and replace engine monitor plug-in printed circuit board. |
| High engine temperature fault lamp lights - no fault condition exists. | Be certain that no fault condition exists. Remove lead 31 from TB11 inside control box (refer to wiring diagram). If high engine temperature lamp still lights, remove and replace engine monitor plug-in printed circuit board. |
| When pressing test lamp button - one or more fault lamps do not light. | Fault lamp/lamps burned out - replace. |
Fault codes and symptom→remedy steps extracted from this model’s service/owner documentation; verify against the official manual before servicing.
Parts
42| Part # | Description | Qty | System | |
|---|---|---|---|---|
| 104-0371 | Motor, Starting | 1 | Pump | PartsGeek |
| 104-0858 | Motor, Starting | 1 | Pump | PartsGeek |
| 140-1089 | Element | 1 | Air filter | PartsGeek |
| 140-1091 | Air Cleaner | 1 | Air filter | PartsGeek |
| 191-0665 | Alternator, Charge (Includes Fan) | 1 | Alternator | PartsGeek |
| 193-0104 | Sender, Oil Pressure Gauge | 1 | Sensor | PartsGeek |
| 193-0108 | Sender, Oil Pressure Gauge | 1 | Sensor | PartsGeek |
| 309-0178 | Switch, Thermostatic - High Coolant Temperature Alarm | 1 | Sensor | PartsGeek |
| 309-0179 | Switch, Thermostatic - High Coolant Temperature Shutdown | 1 | Sensor | PartsGeek |
| 416-0530 | Cable, Battery | 1 | Battery | PartsGeek |
| 503-0597 | Air Cleaner Hose | 1 | Hose | PartsGeek |
| 503-0648 | Clamp, Air Cleaner Hose | 2 | Hose | PartsGeek |
| 505-0019 | Bushing, Pipe - Reducer 1/2” to 3/8”, DFBF (1/2” to 3/8”) 505-0131 DFCB, DFCC, DFCE (3/4” to 3/8”) | 1 | Bushing | PartsGeek |
| 130-0351 | Fan Guard - Left Hand | 1 | Service part / kit | PartsGeek |
| 130-0352 | Fan Guard - Right Hand | 1 | Service part / kit | PartsGeek |
| 130-0449 | Cap, Radiator | 1 | Service part / kit | PartsGeek |
| 130-0713 | Radiator | 1 | Service part / kit | PartsGeek |
| 191-1098 | OTY. | 1 | Service part / kit | PartsGeek |
| 193-0202 | Plug, Pipe - Manifold (2") | 1 | Service part / kit | PartsGeek |
| 232-2183 | Part 232-2183 | 1 | Service part / kit | PartsGeek |
| 309-0169 | 1 Begin Spec G 25 26 | 1 | Service part / kit | PartsGeek |
| 312-0058 | Screw (5/16-18 x 3/4"), Terminal Bracket Mounting | 1 | Service part / kit | PartsGeek |
| 332-1292 | Bracket and Terminal Assembly | 1 | Service part / kit | PartsGeek |
| 416-0446 | Cable, Battery (#2/0) 12-1/2" (Jumper) | 32 | Service part / kit | PartsGeek |
| 416-0531 | 11 4W0446 1 %2 403-0!!36 la ~~~ : | 1 | Service part / kit | PartsGeek |
| 502-0058 | Tee, Pipe - Oil Line The Following Is a Special List Of Corros | 1 | Service part / kit | PartsGeek |
| 503-0098 | Hose, Drain | 1 | Service part / kit | PartsGeek |
| 503-0197 | 503-0197 Miscellaneous Engine | 1 | Service part / kit | PartsGeek |
| 504-0011 | Valve, Shutoff (1/2”) | 1 | Service part / kit | PartsGeek |
| 504-0028 | Valve, Radiator Drain | 1 | Service part / kit | PartsGeek |
| 505-0050 | .-- n.-l. . OW-UUCJI | 1 | Service part / kit | PartsGeek |
| 505-0100 | Nipple, Pipe - Close (1/2”) | 1 | Service part / kit | PartsGeek |
| 505-0131 | Bushing, Pipe - Reducer (3/4º to 3/8º) | 1 | Service part / kit | PartsGeek |
| 505-0185 | Adapter, Oil Drain | 1 | Service part / kit | PartsGeek |
| 526-0115 | Washer (5/16 “) | 2 | Service part / kit | PartsGeek |
| 800-0024 | Clamp, Tube Sleeving, 5'Lg | 1 | Service part / kit | PartsGeek |
| 800-0030 | SCREW, HEX CAP | 1 | Service part / kit | PartsGeek |
| 800-0051 | Screw-H}iC(3/8-16xl 1/4) | 1 | Service part / kit | PartsGeek |
| 800-0090 | Cable, Battery - Negative | 1 | Service part / kit | PartsGeek |
| 800-0094 | Screw, Cap – Hex Head (1/2–13 x 2") | 1 | Service part / kit | PartsGeek |
| 850-0045 | Washer, Lock - Spring (1/4" ) | 2 | Service part / kit | PartsGeek |
| 850-0050 | Washer, Lock - Spring (3/8”) | 1 | Service part / kit | PartsGeek |
Service, wear & replacement parts referenced for this model and its engine — confirm the exact part for your serial number. See the full parts catalog to search and cross-reference.
Fuel consumption
| Rating | Load | L/h | gal/h |
|---|---|---|---|
| Prime | 100% | 3.9 | 10.0 |
| Standby | 100% | 3.9 | 10.0 |
Available documents
Operator's manual — 944-0120 Onan DDB Operator's Manual (2-1978) (Cummins/Onan)Owner's manual — 944-0302 Onan DDB Operator's and Parts Manual (4-1974) (Cummins/Onan)