The KASSEC1-189 is a generator-set controller. It is used on generator sets from Katolight, including the KASSEC1-189.
| Symptom | Remedy |
|---|---|
| Blown Fuse on Terminal #1 | Replace fuse with 8 amp fuse. |
| Failure lights | Shorted leads when hooking up or overloaded circuits. |
| Low Battery | Charger not functioning. Corroded or loose battery connection. |
| UNIT CRANKS, DOES NOT START | Fuel Supply: Voltage on Terminal #2 while cranking Empty fuel tank. Air in fuel lines. Wrong pressure on Natural Gas or LPG units. If present may have defective fuel valve, defective ignition system, or loose connection. |
| UNIT STARTS BUT STARTER DOES NOT DISENGAGE | Starter drive could be hanging up or the solenoid on starter is not disengaging. |
| UNIT WILL START THEN FAIL | Loss of Fuel |
| Voltage present at Terminal #7 | Unused Terminal #5 |
| Yaltage at Start Solenoid | Defective starter or solenoid. |
Fault codes and symptom→remedy steps extracted from this controller’s service/owner documentation; verify against the official manual before servicing. Aggregated from the service documentation of generator sets built on this controller.